Hackney Emergency Vehicles

NJPA National Contracts

Model RIV0846-2013

Rescue and HazMat with Automatic Deploy Staircase

Printable Page
w/ Drawings (PDF)

Specifications

FORD F-550 - 2-DR/4WD (Optional extended or 4-door cab available)

XL trim level (XLT available as option)
Prep Package: 47A Emergency Vehicle
Engine: 6.7L Power Stroke 300hp @ 2800rpm; 660lb-ft @ 1600rpm Turbo Diesel
Transmission: Heavy-duty TorqShift 6-speed SelectShift automatic (Optional PTO port available)
Transfer Case: New Venture 273 with electronic shift (rotary control)
Front Axle: 7000# Dana Super 60 drive type
Rear Axle: 14,706# Dana S130 with limited slip differential
Rear Axle Ratio: 4.88
Tires: 225/70R19.5 Traction-BSW
Driver/Passenger Seats: Individual high back vinyl
Alternator (factory installed): Dual 160-amp
Air Conditioner
Exterior Color: Single painted by Ford (Optional repaint available)

FLUID LEVEL DATA PLATE
WELDON VEHICLE DATA RECORDER (VDR) on VMUX LCD control panel displaying:

vehicle speed; acceleration; - deceleration; engine speed; engine throttle position; ABS event; seat occupied status; - seat belt status; master optical warning switch; park brake; service brake; time; date; engine hours

"MUST BE SEATED AND BELTED" - WARNING PLATE
WARNING PLATE - VEHICLE SPECIFICATION DATA with the following vehicle specification data in compliance with NFPA 1901-2009, section 12.1.5.1 and section 14.1.2:

Vehicle Height; Vehicle Length; Gross Vehicle Weight Rating (GVWR); Vehicle Occupancy Maximum

"DO NOT WEAR HELMET WHILE SEATED" - WARNING PLATE
HELMET HOLDER behind each cab seat
EXHAUST PIPE EXTENSION BEHIND RIGHT REAR WHEELS
DEF TANK RELOCATION W/FILLER PORT
BATTERY CONDITIONER - 45-amp
SHOREPOWER INLET, 20 AMP W/COVER & FEMALE PLUG
ENGINE COMP'T LIGHT W/SWITCH - 5" (2)
STEP LIGHTS - LED FRONT CAB DOOR (PR) - Automatically activated when left and right front cab doors are opened and respective side scene lights are activated
MUD FLAPS, FRT (PR) Black Rubber
TIRE PRESSURE MONITORING - ACCU-PRESSURE CAP - 6-wheel
TOW EYE PLATES - REAR - BLACK (PR)

Bolted to frame channels extending through rear body panel
Powder-coated black
5"H x 1" thick with 3" diameter hole

BODY – Rapid Intervention with Open Bed

Compartment modules formed of 5052-H32 aluminum
All compartments rated at a minimum of 800 lbs load capacity each
Smooth aluminum reinforced floors
Bright aluminum tread plate roof

Spring-loaded mounting system
Includes roll up doors

BODY CONFIGURATION:
Streetside (Left) Interior Dimensions:
S1 - 33.5" wide x 50.8" high x 21.5/91" deep
S2 - 21" wide x 50.8" high x 19.5"/21.5" deep
S3 - 37" wide x 25.875" high x 21.5" deep
S4 - 35.5" wide x 50.8" high x 19.5/21.5" deep

Streetside (Left) Door Opening (pass-thru) Dimensions:
S1 - 30.5" wide x 45.5" high
S2 - 18" wide x 45.5" high
S3 - 34" wide x 20.5" high
S4 - 32.5" wide x 45.5" high

Curbside (Right) Interior Dimensions:
C1 - 33.5" wide x 50.8" high x 21.5/91" deep
C2 - 21" wide x 50.8" high x 19.5"/21.5" deep
C3 - 37" wide x 25.875" high x 21.5" deep
C4 - 35.5" wide x 50.8" high x 19.5/21.5" deep

Curbside (Right) Door Opening (pass-thru) Dimensions:
C1 - 30.5" wide x 45.5" high
C2 - 18" wide x 45.5" high
C3 - 34" wide x 20.5" high
C4 - 32.5" wide x 45.5" high

Rear Compartment Dimensions:
B-1: 48" wide x 41.8" high x 104" deep (Open Bed) – will accommodate skid pump and 300-gallon tank

Hansen Hackney Roll-up Doors (8)

includes front roll type; recessed track style; standard drip rail with
Brushed finish; 12-volt door ajar switches
LED strip lighting

FENDERETTES, BLACK RUBBER (PR) – Optional stainless steel available)
FUEL FILLER W/HINGED ACCESS DOOR
ULTRA-LOW SULFUR DIESEL FUEL ONLY LABEL
STONE GUARDS, FRT & REAR - D/P CORNERS (4)
CRASH RAILS - C-CHANNEL LOWER SIDE BODY (set of 4)

Stainless steel fasteners
Nylon washer isolators
Powder coated silver

BUMPER, REAR STEP
-- Center section recessed to within 5" off body for close proximity to pump controls
SIGN - "DANGER - DO NOT RIDE ON REAR STEP"

WHEEL CHOCK - ZICO AC-2 (2)
WHEEL CHOCK BRACKET - HORIZONTAL FOR ZICO AC-2
LICENSE FRAME W/LIGHT-SURFACE MNT-CPI C30004 1
MUD FLAPS, REAR (PR) BLACK RUBBER
UNISTRUT "C" CHANNEL (set of 4) - up to 30"L

UNISTRUT "C" CHANNEL (set of 4) - up to 50"L

SHELF - EXTENDED FLOOR - PERMANENT

S-1 - fixed at frame level
S-2 - fixed at frame level
C-1 - fixed at frame level
C-2 - fixed at frame level

PART NO DESCRIPTION QTY

ELECTRICAL SYSTEM - VISIONMUX

Electrical distribution panel located in the forward wall of C-1 compartment
Features 9-position switch panel panel mounted in center console; switches to illuminate in the center when activated
Engine automatic high idle
Built in load manager
Low volt alarm in front of cab console

Switch Panel:
-- TOP ROW LEFT:
#1 - E MASTER
#2 - BLOCKING OVERRIDE
#3 - SPARE
-- TOP ROW RIGHT:
#4 - SS POLE LIGHT
#5 - CS POLE LIGHT
#6 - SPARE
-- BOTTOM ROW LEFT:
#7 - LEFT SCENE
#8 - RIGHT SCENE
#9 - REAR SCENE

AMP DRAW REPORT - NFPA 1901, Section 9-15 1
CAB CONSOLE - FLOOR MOUNT: Havis-Shields model #1C-3010 console with model #C-AP-1395-L accessory pocket with Lid; black powder-coated finish; minimum 13" long x 8" wide carpeted storage compartment with lockable hinged lid; C-MC - Mike Clip; C-ML-LP2 - Flexshaft map light and (2) 12VDC power point receptacles
CLEARANCE LIGHTS, LED & REFLECTORS1
CLEARANCE LIGHTS, LED – Center of step bumper
TAIL LIGHT ASSY - LED STOP/TURN/BACKUP- SOUNDOFF SIGNAL - Recessed into rear body panel -

Individual red LED stop/tail light
Individual amber LED turn signal
Individual white LED backup
six (6) chrome dress rings

SCENE LIGHT - SIDE - WHELEN 70 LED OPTI-SCENE W/15-DEGREE CHROME HOUSING (2)

Whelen #70C0ELZR surface mount LED Opti-Scene light with CPI LH37203-1 15-degree chrome housing
Surface mounted on upper left and right side of body
Locations: (1) Streetside and (1) Curbside as per drawing

SCENE LIGHT - REAR - WHELEN 70 LED OPTI-SCENE W/15-DEGREE CHROME HOUSING (2)

15-degree chrome housing
Surface mounted on upper left and right side of body

COMPARTMENT LIGHTS - LED STRIP (8)
COMP'T OPEN WARNING & AUTO

Activation switch incorporated into the "Door Open" circuit.
In the event a door is not properly closed and/or secured a red blinking light will activate

COMP'T OPEN WARNING LIGHT

WHELEN LFL LIBERTY SLN2QLED - 54" LIGHT BAR
WHELEN 70R02FRR LINEAR SUPER-LED (2) – in grille
WHELEN 50R03ZRR TIR6 SUPER-LED – (1) each side cab fender
WHELEN 50R03ZRR TIR6 SUPER-LED (1) each rear wheel skirt panel
WHELEN 60R02FRR LINEAR SUPER-LED (2) upper rear body
SIREN - ELECTRONIC WHELEN - 295SLSA1
SPEAKER, SIREN - F-550 - THROUGH-THE-BUMPER (DRIVER)

12VDC POWER STRIP - (6) TERMINALS – CAB – for radio and accessory connections
BACK-UP ALARM
REARVIEW COLOR CAMERA W/NIGHTVISION & MONITOR